NON DESTRUCTIVE TESTING IN RAILWAY BRIDGES

1. NON DESTRUCTIVE TESTINGIN RAILWAY BRIDGES

2. INTRODUCTION • Non – Destructive testing [NDT] is an activity to assess the variation from the design and monitor performance. • With the increasing number of structures showing signs of distress a greater need is felt to apply more advance assessment techniques and equipment in the bridge inspection. • This presentation focuses on the available techniques , and two nos case studies of NF Railway , where the NDT has been used successfully.

3. NDT Techniques

4. NDT Techniques [… Contd]

5. NDT in NF Railway` • Of the above NDT techniques so detailed , NF Railway has gained some experience in the following techniques A. Rebound Hammer Test B. Core Test C. Ultra Sound Pulse Velocity Method D. Integrity Testing of Piles E. Chemical Analysis of the Concrete Material

6. NDT in NF Railway • The experienced so gained in the last two years on NF Railway shall be explained in the remaining part of the presentation using two nos case studies of NF Railway

7. NDT in NF Railway --- Br No 40 • Br No 40 is an Important Bridge on New Jalpaiguri – New Bongaigaon section of NF Railway having an span of 20 x 150 feet over Teesta River. Its design discharge is 700000 cusecs. It has Cement Concrete Well Foundation designed for BGML Standard with 30 Feet Well Dia and 100 feet depth of well below HFL. The bridge was initially constructed as 13x150 feet spans . During 1988 floods eastern approach was washed away and the bridge was extended by 7 spans of 150ft on the east in 1975. • For the last few years cracks were developing on Pier No. P1, P2 , P3 and P4.

8. NDT in NF Railway --- Br No 40 PANORAMIC VIEW OF BRIDGE NO 40

9. NDT in NF Railway --- Br No 40 ZIG ZAG CRACK PATTERN

10. NDT in NF Railway --- Br No 40 CRACKS IN WELL CAP

11. NDT in NF Railway --- Br No 40 SHOWING CASTING LIFT VARIATIONS

12. NDT in NF Railway --- Br No 40 HORIZONTAL CRACKS FORMED DUE TO SEPERATION OF COLD JOINT IN COURSE OF TIME

13. NDT in NF Railway --- Br No 40 CRACK MAGNIFIED

14. NDT in NF Railway --- Br No 40 SEVERE VERTICAL CRACKS

15. NDT in NF Railway --- Br No 40 CRACKS CONCENTRATION FROM DIFFERENT DIRECTIONS , RESULTING IN SEVERE DETERIORATION AT MEETINGPOINT

16. NDT in NF Railway --- Br No 40 • These cracks were prominent in Piers P1, P2, P3 and P4. • After this visual examination , certain points remained unanswered • It was not clear , as to what was the depth of these cracks? • What was the resultant compressive strength of the concrete mass used in Pier? • Whether the concrete has undergone any long term deterioration due to excessive sulphur or chloride content?

17. NDT in NF Railway --- Br No 40 • In order to assess the above points it was decided to undertake the following examinations • Ultrasonic Pulse Velocity Test • Concrete Core extraction for evaluation of compressive strength • Chemical Analysis to ascertain approximate mix proportions of concrete

18. NDT in NF Railway --- Br No 40 • M/s S. K. Mitra and Associates of Kolkatta were entrusted the work, who carried out the same in March – April 2003 • Test Methods and the deductions on the basis of the test results are explained in the following slides.

19. NDT in NF Railway --- Br No 40Ultrasonic Pulse Velocity Test • The aim of the Ultrasound pulse velocity test was to identify weak locations possessing loss of integrity , presence of void , quality of concrete and depth of cracks which could not be ascertained by visual inspection. • The ultrasonic pulse is generated by an electro-acoustical transducer. When the pulse is induced in the concrete from a transducer, it undergoes multiple reflections at the boundaries of the different material phases within the concrete. A complex system of stress waves is generated which includes longitudinal , shear and surface waves. The receiving transducer detects the longitudinal waves which is the fastest.

20. NDT in NF Railway --- Br No 40Ultrasonic Pulse Velocity Test • The velocity of an ultrasonic pulse through any material depends upon its density , modulus of elasticity , presence of reinforcement steel and Poisson’s ratio. • The underlying principle of assessing the quality of concrete is that comparatively higher velocities are obtained when the quality of concrete in terms of density , homogeneity and uniformity is good. In case of poorer quality , lower velocities are obtained. • If there is a crack , void or flaw inside the concrete which comes in the way of transmission of the pulses, the pulse strength is attenuated and lower velocities are obtained,

21. NDT in NF Railway --- Br No 40Ultrasonic Pulse Velocity Test

22. NDT in NF Railway --- Br No 40Ultrasonic Pulse Velocity Test-Interpretations • There are two dimensions to the result interpretation • First – General Quality Assessment of Concrete- The velocity ranged fro 3.1 to 4.0 Km/sec. This indicates that quality of concrete was good to very good • Second- Depth of Crack – It was assessed based on the velocity of propagated waves on both sides of the crack. Crack Depth were found to be varying from 31mm to 684 mm .

23. NDT in NF Railway --- Br No 40Concrete Core Extraction • The basic purpose to extract cores was to evaluate directly the compressive strength of concrete on the basis of cylinder strength and co-relate it to conventional cube strength. • This gives fairly a good idea about the compressive strength reached

24. NDT in NF Railway --- Br No 40Concrete Core Extraction CORE DRILLING IN OPERATION

25. NDT in NF Railway --- Br No 40Concrete Core Extraction CORE LOCATION AFTER DRILLING

26. NDT in NF Railway --- Br No 40Concrete Core Extraction • 5 Cores of 55mm Diameter were extracted. • To assess crushing strength , cores were trimmed at the end and tested for voids and density also. Prior to test , cores were capped with sulphur and tested after soaking for 48 hours • Equivalent concrete cube strength was assessed as per IS 516-1959. The results obtained were found nearer to M-20 grade concrete. • As per the completion plan , a mix proportion of 1:3:6 is mentioned in the drawing for construction of pier , and the bed block and well cap was constructed using mix proportion of 1:2:4. The test results confirmed that the compressive strength of the concrete is above the assumed value.

27. NDT in NF Railway --- Br No 40Concrete Core Extraction- Test Results

28. NDT in NF Railway --- Br No 40Chemical Analysis • The aggregates of Cement Concrete sample was separated from the mortar mechanically and chemical analysis of mortar portion of the cement concrete was carried out generally on the lines of ASTM C-85-66. • PH value , Chloride content and the Sulphate Content were analysed.

29. NDT in NF Railway --- Br No 40Chemical Analysis- Test Results

30. NDT in NF Railway --- Br No 40Chemical Analysis- Test Results • As per IS 456 -2000 , the PH should not be less than .Test results reveals that concrete is basic in nature and so no deterioration due to acidic nature was envisaged. • As per IS 456 – 2000 , the chloride content should be below 3000 ppm . In all the samples the Chloride content was found to be much below this • The limiting value of the sulphate content is 4000 ppm . In this case the sulphate content were found to be near or slightly more than the limiting value. As per IS 456-1978 , higher values of sulphates can cause expansion and disruption of concrete.

31. NDT in NF Railway --- Br No 40Chemical Analysis- Test Results • IS 456-2000 Clause 8.2.5.4 states that, some aggregates containing particular varieties of silica may be susceptible to attack by alkalis originating from cement and other sources producing an expansive reaction which can cause cracking and disruption of concrete. • Aggregates retrieved from the extracted core was subjected to aggregate reactivity test as per IS:2386 and the results ruled out the possibility of Alkali- Aggregate reactivity

32. NDT in NF Railway --- Br No 40CONCLUSIONS • Compressive Strength of Concrete was found to be more than the design value. • Crack depth was found to be varying between 31mm to 684 mm • Horizontal Cracks , noted in between the lifts of casting in some cases were due to cold joints formed during construction. • Higher sulphate content might have resulted in the cracks.

33. NDT in NF Railway --- Br No 184 • Br No 184 is a major bridge in Guwahati – Lumding section of NF Railway . This has span of 1x 12.20m and 3x 18.30m . The bridge was built between 1930-1935 . It is having well foundations • Interestingly the bridge pier is of concrete with one brick thick cladding all around the pier. • AEN/Lumding reported a hollow echoing sound emanating from the piers peropheri , when the piers were struck by hammers at different points along the cross section and height of the piers.Sectional Sr DEN imposed a restriction of 20 kmph over the bridge. The Division proposed rebuilding of the bridge at an approximate cost of Rs 5.16 Crores

34. NDT in NF Railway --- Br No 184 • CBE’s inspection revealed that apart from the usual weathering of the bricks , there was no distress noticeable on the outer face of the piers where the hollow sounds were coming from • CBE decided to carry out the NDT and have an insight into the bridge structural behaviour before going for the complete rebuilding.

35. NDT in NF Railway --- Br No 184 • M/s S K Mitra & Associates were entrusted to carry out the NDT using the following techniques • Ultra sound pulse velocity test • Core extraction and Testing • Chemical test to evaluate sulphate . Chloride content and PH value

36. NDT in NF Railway --- Br No 184UPV Test MEASURING ULTRA SONIC PULSE VELOCITY

37. NDT in NF Railway --- Br No 184UPV Test MEASURING PULSE VELOCITY

38. NDT in NF Railway --- Br No 184UPV Test

39. NDT in NF Railway --- Br No 184UPV Test • Interestingly , the velocity of pulse ranged from 0.668 to 1.45km/sec for Pier No 2 and from 0.673 to 1.32 Km/sec for Pier No P3 • This placed the concrete quality as doubtful according to the UPVvalues as per IS:13311(Part I) • Next Logical step was to carry out the Concrete Core Strength Tests and do the Chemical Analysis.

40. NDT in NF Railway --- Br No 184CONCRETE Core Cutter Test CORE EXTRACTION IN PROGRESS

41. NDT in NF Railway --- Br No 184CONCRETE Core Cutter Test AFTER CORE EXTRACTION

42. NDT in NF Railway --- Br No 184CONCRETE Core Cutter Test • Total 7 Nos cores of 50 mm dia were extracted. Out of these , 2 Cores were extracted from the brick layer to assess the quality of the bricks • In all cases , water absorption test was carried out and strength determined as per the procedure described in IS:516. To assess crushing strength , cores were trimmed at the end and tested for void and density.

43. NDT in NF Railway --- Br No 184CONCRETE Core Cutter Test

44. NDT in NF Railway --- Br No 184CONCRETE Core Cutter Test • The results obtained were nearer to M15 , excepting in two cases where these were found nearer to M10 and M40 respectively. • Hence the quality of concrete was found to be good in general • Concrete cores also displayed a lot of voids and honeycombing at the interface of the concrete core and brick cladding.

45. NDT in NF Railway --- Br No 184Chemical Analysis • From the cores extracted , the aggregate was separated from the mortar • From the chemical test result it was concluded that , the concrete was basic in nature. Chloride and Sulphate content of the concrete was well below the limit prescribed by IS456.

46. NDT in NF Railway --- Br No 184Condition Monitoring and Useful Life Assessment • The results as obtained were conveyed to Prof P. Banerjee of IIT-Powai. Pixel Networks of Mumbai arranged for the site visit and investigation of the bridge . • On 14th January 2004, Prof Banerjee visited the site and . Two more cores were extracted from the bridge in his presence as requested by him. • He submitted his detailed report afterwards

47. NDT in NF Railway --- Br No 184CONCLUSIONS based on the NDT and Prof Banerjee’s Report • The hollow sound emanating form the pier was due to the voids and honeycombing formed at the face of pier and brick cladding. • Lower pulse velocity was also due to the voids and honeycombing at the interface • Concrete Core was of fairly good quality and was found to be having sufficient strength to carry the present day loading • There was no deterioration due to acidity , higher chloride content or higher sulphate content.

48. NDT in NF Railway --- Br No 184CONCLUSIONS based on the NDT and Prof Banerjee’s Report • While calculating the strength of the bridge it was assumed that the brick cladding was not participating in any load sharing arrangement. • Hollow sound was not a cause of concern. • The Railway got confidence in the structural integrity of the bridge and the rebuilding of the bridge was not considered necessary

49. NDT in NF Railway --- Br No 184 • The Cost of the NDT was Rs 1.6 Lakh and the cost of Conditional monitoring by Prof Banerjee was Rs 2.5 Lakh • The cost of rebuilding of the bridge was Rs 5.2 Crores. • Not only the NDT resulted in the huge saving , it also initiated an approach which is scientific , logical and extends beyond the realms of judgments based solely on the visual examinations

50. THANK YOU